In this products liability case, we hold that the district court appropriately and fairly granted summary judgment for the defendants. The plaintiffs are the heirs of Marvin Joe Little and Charles Carter. Little and Carter were experienced welders working in the wingtank of a barge. At some point, a gas hose leading to their welding torch developed a leak. The welding torch was manufactured by defendant Victor Manufacturing Company; the gas was manufactured by defendant Chevron Chemical Company and sold by defendant Liquid Air Corporation. The plaintiffs contend that, because of nasal fatigue, Little and Carter did not smell the gas, and that Carter lit a cigarette, causing an explosion that resulted in their deaths.1 The heirs assert that Chevron and Liquid Air are liable because the warning accompanying the gas failed to warn of nasal fatigue; and that Victor is liable because a defective torch caused a "flashback" and a tear in the gas hose line, which resulted in the gas leak, which was a proximate cause of the deaths. When these allegations were put to the test of summary judgment, however, the plaintiffs failed to come forward with any evidence supporting their theory of recovery, that is, evidence that Little and Carter actually suffered nasal fatigue and that nasal fatigue bore a causal connection to their deaths; they likewise failed to establish liability against Victor. In our opinion today, we emphasize that summary judgment should be granted and will be affirmed by this court when the nonmoving party fails to meet its burden to come forward with facts and law demonstrating a basis for recovery that would support a jury verdict. We thus reject the reasoning of the panel and affirm the district court.

* In July 1988, Marvin Joe Little and Charles Carter were employed by Mainstream, Inc. where they were cleaning the wingtanks of a barge.2 Both Little and Carter were experienced welders who, according to their employer, had been properly trained and instructed as to the proper use of propylene gas. In their work, they were using a cutting torch manufactured by defendant Victor. The torch was attached to two hoses, one for oxygen and one for propylene gas, both of which were connected to tanks on the main deck of the barge. The propylene gas was manufactured by Chevron, which supplied it to Liquid Air, which provided it to Mainstream through a distributor. Prior to distribution by Chevron, the propylene gas was odorized with ethyl mercaptan, which gives the gas the smell of rotten eggs.

Chevron had sold the propylene gas to Liquid Air in bulk tank truckloads and, with each delivery, provided Liquid Air with Chevron's Material Safety Data Sheet ("MSDS") that included the following warning:

Precautions if Material is Released or Spilled: Eliminate all sources of ignition in vicinity of spill or released vapor. Evacuate the area immediately and do not allow anyone to return until it is safe to do so. Persons entering the area to correct the problem and determine whether it is safe for normal activities to resume must comply with all instructions in Special Protective Information.3

When Liquid Air sold the propylene gas to Mainstream under its own name through a distributor, it was accompanied by Liquid Air's MSDS that provided in part:

STEPS TO BE TAKEN IN CASE MATERIAL IS RELEASED OR SPILLED: Evacuate all personnel from affected area. Use appropriate protective equipment. Do not get liquid in eyes, on skin or clothing. Shut off source of leak if possible. Protect from ignition. Ventilate area thoroughly. If leak is in user's equipment, be certain to purge piping with an inert gas prior to attempting repairs. If leak is in container or container valve, contact the closest Liquid Air Corporation location.

Although Little and Carter were never specifically advised that propylene gas could cause nasal fatigue, every Mainstream employee who testified stated that he knew to evacuate the wingtank if they smelled gas or had a leak.

On July 8, 1988, Little and Carter returned from lunch at approximately 12:30 and climbed into the No. 9 wingtank to continue their work. The wingtank hatch was a manhole approximately 18 to 20 inches in diameter, and a part of that hatch was occupied with a ventilation fan. Earnest Hughes, a co-worker of Little and Carter, walked to the hatch of the No. 9 wingtank some few minutes after returning from lunch and was summoned by Little to get the torch and hose out of the wingtank because the hose was leaking gas. At that time, Carter was back into the wingtank so far that Hughes could not see him and Little was partway down the ladder leading into the fourteen-foot deep wingtank. Little was into the wingtank--his head beneath the hatch about a foot or two--when he told Hughes that there was a hole in the torch's gas line.

Hughes pulled the torch and gas lines out of the wingtank and then laid them on the deck of the barge. He noticed the hole in the gas line. Little, still on the ladder in the hole, then told Hughes to get a repair kit to fix the hose. Hughes left to get the repair kit and, about half a minute later, heard a noise. When he looked back, he saw the fan--which had been attached at the top of the hatch--being blown into the air and then saw Little being propelled out of the wingtank. Hughes ran for help and cut all the gas off. Little died immediately and Carter died several days later as a result of burns that he received in the explosion.

* The families of Carter and Little initiated actions for damages resulting from the explosion. The actions were consolidated and, after some initial discovery, the complaints stated claims against Victor, Chevron, and Liquid Air. In the amended complaint,4 the plaintiffs alleged that

On July 8, 1988, Marvin Joe Little and co-employee Charles Carter were working in the hold of a barge doing repair work, including the use of a cutting and welding torch manufactured by Victor. Little was also using propylene (Fuel Gas) manufactured by Chevron and distributed and sold by Liquid Air. The hold was an enclosed area below decks of the barge constructed for the purpose of buoyancy. Except for a single hatch, there was no ingress or egress to this hold. Little and Carter discovered a gas leak and decided to remove the torch from the hold to repair the hose. A short time after the hose was removed, no longer smelling the gas and believing the area to be safe, Carter lit a cigarette. This source of ignition led to an explosion of the propylene gaseous mixture which blasted Little's body through the hatchway of the hold, killing him instantly. Carter was seriously burned by the explosion and died several days later.

With respect to defendant Victor, the amended complaint alleged that the gas leak was caused by the "defective and negligent design of the torch"; specifically, the torch was defective in that it had a leaking O-ring and a leaking check valve, which defects caused a flashback that lead to a leak in the gas hose. The amended complaint further alleged that the propylene gas manufactured and distributed by Chevron and Liquid Air was defective and unreasonably dangerous because

exposure to this gas leads to nasal fatigue to the extent that a worker cannot reliably detect this gas by smell. At the time he lit the cigarette, Carter could no longer smell the gas because of nasal fatigue. Both Carter and Little were unaware of the propensity of Defendants' gas product to cause nasal fatigue and were further unaware that exposure to this gas reduces or eliminates the ability to smell the gas.5

After the parties had engaged in discovery, the defendants moved for summary judgment.6 The plaintiffs responded, urging that they should be allowed to amend their complaint to assert different theories of liability and that, even without the proposed amended complaint, there was sufficient evidence from which a jury could reach a verdict in their favor. In a well-reasoned opinion, the district court granted the motions and dismissed the plaintiffs' claims. The district court first held that Chevron and Liquid Air were entitled to the bulk seller/sophisticated purchaser defense. With respect to Chevron and Liquid Air, the district court also held that the plaintiffs had failed to present proof of the inadequacy of the warnings and the causative nexus between the warning and the injury suffered. The district court finally held that the plaintiffs had failed to offer proof that the defective Victor torch was the proximate cause of their injury.

The panel7 first held that the district court did not abuse its discretion in denying the plaintiffs' motion to amend their complaint.8 952 F.2d at 845-47. Next, observing that summary judgment is rarely appropriate in products liability cases, the panel held that the burden did not shift to the plaintiffs to produce summary judgment proof because the defendants did not discharge their burden to establish that the plaintiffs did not raise a genuine question of material fact. Bolstering this conclusion, the panel majority postulated a set of "facts"9 that, according to the panel, would allow the plaintiffs to prevail at trial in strict liability and negligence on the theory that the warning was inadequate concerning nasal fatigue: Little and Carter discovered the leak and caused the hose to be removed from the wingtank; they then could no longer smell the gas and, assuming the fan had dissipated the odor,10 remained in the wingtank temporarily rather than following the leaky hose to the deck of the barge; the wingtank then exploded as they attempted to leave. Recognizing that circumstantial evidence is admissible in Mississippi to establish strict liability, the panel noted that evidence that Carter perhaps lit a cigarette is circumstantial evidence that he could no longer smell the gas;11 evidence that Little was standing on the ladder to the wingtank is circumstantial evidence that he and Carter were attempting to leave.12

Based on this strained and unsupported factual scenario, the panel concluded that the warnings provided by Liquid Air and Chevron were not inadequate as a matter of law, but also not so conclusively adequate as to require summary judgment in their favor. In summary, the panel held that a "jury should determine whether the defendants' failure to warn that propylene can cause nasal fatigue was a breach of their duty to warn of all dangers of which they had actual or constructive knowledge." 952 F.2d at 850.13

With respect to defendant Victor, the panel held that the district court erred in holding that the allegedly defective torch was not the proximate cause of the accident because of the intervening conduct of the plaintiffs in failing to follow the warning to evacuate the tank immediately. The district court erred because there was evidence to question whether the failure of Little and Carter to evacuate immediately was negligence or, on the other hand, an attempt to follow the warning. 952 F.2d at 852.

Judge Garwood dissented. He argued that the plaintiffs failed to discharge their burden of coming forward with sufficient evidence to permit a jury to find in their favor because it was undisputed that Carter and Little knew of the gas leak, that they knew it was present in the wingtank and that the explosion occurred very shortly thereafter. Therefore, according to Judge Garwood, it was "purest speculation" to assume that Little and Carter were suddenly afflicted with nasal fatigue. Further, the warning was not heeded when Carter lit a cigarette and also when Little and Carter delayed their departure from the wingtank. Accordingly, Judge Garwood would have affirmed the district court.

On suggestion for rehearing en banc, a majority of this court reflected the view that because summary judgment was so plainly appropriate, en banc consideration was necessary so that district courts will not be misdirected from the lesson of Celotex and its progeny that summary judgment is and should be "an integral part of the Federal Rules as a whole, which are designed 'to secure the just, speedy and inexpensive determination of every action.' " Celotex Corp. v. Catrett, 477 U.S. 317, 327, 106 S. Ct. 2548, 2555, 91 L. Ed. 2d 265 (1986).B

For many years, we and other circuits viewed summary judgment as a "disfavored procedural shortcut," applicable to a limited class of cases. Armstrong v. City of Dallas, 997 F.2d 62 (5th Cir.1993). See Fontenot v. Upjohn Co., 780 F.2d 1190, 1197 (5th Cir.1986) (noting ambivalence toward summary judgment for fear that trial judges use it as "catch penny contrivance to take unwary litigants into its toils and deprive them of a trial"). Beginning with its summary judgment "trilogy," Celotex Corp. v. Catrett, 477 U.S. 317, 106 S. Ct. 2548, 91 L. Ed. 2d 265 (1986); Anderson v. Liberty Lobby, Inc., 477 U.S. 242, 106 S. Ct. 2505, 91 L. Ed. 2d 202 (1986); Matsushita Electric Industrial Co. v. Zenith Radio Corp., 475 U.S. 574, 106 S. Ct. 1348, 89 L. Ed. 2d 538 (1986), the Supreme Court, however, has made it clear that our earlier approach to Rule 56 was wrong-headed because it was simply inconsistent with the plain language of the rule.

The Supreme Court has instructed us that the purpose of Rule 56 is to "enable a party who believes there is no genuine dispute as to a specific fact essential to the other side's case to demand at least one sworn averment of that fact before the lengthy process of litigation continues." Lujan v. National Wildlife Federation, 497 U.S. 871, 888, 110 S. Ct. 3177, 3189, 111 L. Ed. 2d 695 (1990). To be certain, Rule 56 "mandates the entry of summary judgment, after adequate time for discovery and upon motion, against a party who fails to make a showing sufficient to establish the existence of an element essential to that party's case, and on which that party will bear the burden of proof at trial." Celotex, 477 U.S. at 322, 106 S.Ct. at 2552 (emphasis added). Plainly, Rule 56 means what it says: "judgment ... shall be rendered forthwith if the pleadings, depositions, answers to interrogatories, and admissions on file, together with the affidavits, if any, show that there is no genuine issue as to any material fact and that the moving party is entitled to a judgment as a matter of law." Fed.R.Civ.P. 56(c) (emphasis added).

Furthermore, the party moving for summary judgment must "demonstrate the absence of a genuine issue of material fact," but need not negate the elements of the nonmovant's case. Celotex, 477 U.S. at 323, 106 S.Ct. at 2553; see Lujan, 497 U.S. at 885-86, 110 S.Ct. at 3187. If the moving party fails to meet this initial burden, the motion must be denied, regardless of the nonmovant's response. If the movant does, however, meet this burden, the nonmovant must go beyond the pleadings and designate specific facts showing that there is a genuine issue for trial. Celotex, 477 U.S. at 325, 106 S.Ct. at 2553-54.

This burden is not satisfied with "some metaphysical doubt as to the material facts," Matsushita, 475 U.S. at 586, 106 S.Ct. at 1356, by "conclusory allegations," Lujan, 497 U.S. at 871-73, 110 S.Ct. at 3180, by "unsubstantiated assertions," Hopper v. Frank, 16 F.3d 92 (5th Cir.1994), or by only a "scintilla" of evidence, Davis v. Chevron U.S.A., Inc., 14 F.3d 1082 (5th Cir.1994). We resolve factual controversies in favor of the nonmoving party, but only when there is an actual controversy, that is, when both parties have submitted evidence of contradictory facts. We do not, however, in the absence of any proof, assume that the nonmoving party could or would prove the necessary facts. See Lujan, 497 U.S. at 888, 110 S.Ct. at 3188 (resolving actual disputes of material facts in favor of nonmoving party "is a world apart from 'assuming' that general averments embrace the 'specific facts' needed to sustain the complaint.... It will not do to 'presume' the missing facts because without them the affidavits would not establish the injury that they generally allege").

Moreover, the nonmoving party's burden is not affected by the type of case; summary judgment is appropriate in any case "where critical evidence is so weak or tenuous on an essential fact that it could not support a judgment in favor of the nonmovant."14 Armstrong v. City of Dallas, 997 F.2d 62 (5th Cir.1993). If the nonmoving party fails to meet this burden, the motion for summary judgment must be granted.

Our application of Rule 56 today--mandated by the Supreme Court--finds support in principles of fairness and judicial economy, particularly in the light of backlogs in the district courts and the high cost of litigation. A plaintiff should not be required to wait indefinitely for a trial when the defendant has a meritless defense that can be resolved on motion for summary judgment. Nor should a defendant be required to bear the unnecessary costs of delay and trial to defend against a claim that has no merit. Neither party should be required to bear the costs of trying all of the issues in a case when some can and should be resolved on summary judgment. Nor is it fair to require other cases to languish on the district courts' trial dockets because of cases that present no genuine questions of material fact. As Judge Rubin stated for this court in Fontenot, 780 F.2d at 1195, "[T]rial would be a bootless exercise, fated for an inevitable result but at continued expense for the parties, the preemption of a trial date that might have been used for other litigants waiting impatiently in the judicial queue, and a burden on the court and the taxpayers."

Notwithstanding the long history of summary judgment procedure, some parties will always complain that summary judgment unfairly deprives a party of the right to have the case heard by the trier of fact. No one, however, should be heard to question the fairness of requiring a party to meet basic evidentiary and procedural burdens in the trial of a case. Summary judgment requires no more. If, after adequate time for discovery, a party cannot produce proof that it has facts to support its case, then the case should be resolved at that point, and this is true irrespective of the type of case.

With these principles in mind, we turn to examine this case.

The plaintiffs' claims, both before the district court and before this court, are framed by their allegations and theories reflected in the amended complaint--the propylene gas manufactured by Chevron and distributed by Liquid Air was defective in only one respect: the failure to warn of nasal fatigue.15 In order to recover under this theory, obviously there must be a causal connection between the defect and the injury. Wyeth Laboratories, Inc. v. Fortenberry, 530 So. 2d 688, 691 (Miss.1988) (plaintiff must show that adequate warning would have altered conduct); Thomas v. Hoffman-LaRoche, Inc., 949 F.2d 806 (5th Cir.1992) (same); Fairley v. American Hoist & Derrick Co., 640 F.2d 679, 681 (5th Cir.1981) (showing defect is not enough if it did not cause or contribute to cause of injury). See also Willett v. Baxter International, Inc., 929 F.2d 1094, 1098 (5th Cir.1991) (defective aspect of product must cause injury in failure to warn case). The plaintiffs' argument fails because no evidence supports that Little or Carter suffered nasal fatigue and, consequently, there is no evidence that nasal fatigue was the proximate cause of their deaths.16

The plaintiffs concede that they offered no direct evidence that Little and Carter ever actually suffered from nasal fatigue. They argue, however, that we can infer that Carter and Little suffered nasal fatigue from the facts that they did not evacuate and that Carter lit a cigarette. Any inference drawn from these facts, even assuming that the underlying facts are supported in the record, at best proves only that the cause of their injuries was the failure to smell the gas, not that the cause of their failure to smell the gas was nasal fatigue. Thus, evidence establishing a causal connection between the alleged defect in the warning and the injury suffered is lacking.

The facts of this case fail to reveal any explanation for the conduct of Little and Carter or the cause of the accident. Indeed, the evidence does not reveal with any degree of certainty whether Carter and Little did or did not smell the gas.17 In this respect, the record is clear on only one point: they were aware of the gas leak because they had discovered the hole in the gas hose. Beyond that, the facts in the record lead only to speculation as to why Little and Carter did not immediately evacuate the wingtank when they knew of the gas leak. Nasal fatigue is only one speculative theory, neither more nor less supportable in this record than any of the other speculative theories.18

There was, for example, testimony speculating that the gas may have sufficiently dissipated so that it was on the floor and could not be smelled; there was testimony speculating that the ventilating fan may have drawn out the odor from the tank; and there was testimony speculating that the odorant may have failed altogether. Furthermore, it is equally easy to speculate that Little and Carter may have smelled the gas but remained in the tank temporarily rather than climbing out because they did not anticipate an igniting source.19

Moreover, when placed in the context of this case, the testimony of the plaintiffs' expert on nasal fatigue, Charles Phillip Colver, does not support nasal fatigue as a theory explaining why Little and Carter remained in the wingtank.20 He testified that whether and when nasal fatigue may occur depends on the length of time of exposure and the strength of the odorant, as well as the particular individual who is exposed to the odorant. Yet, the record is silent concerning how any of these factors apply in this case. The record contains no facts concerning time of exposure,21 the volume of the gas leaked, the temperature, the effect of the ventilation fan and, consequently, the strength of the odorant at the time of exposure. Nor do we know to what extent Little's and Carter's individual olfactory senses were susceptible to the phenomenon of nasal fatigue.

Finally, we cannot infer that Carter and Little smelled the gas from the alleged fact that Carter lit a cigarette because no evidence was adduced before the district court that Carter did light a cigarette.22 At best, the record shows that Carter was a smoker, that he had smoked earlier in the day, that he bought a pack of cigarettes and perhaps a lighter at lunch and that there were smoked cigarette butts on the floor of the wingtank after the explosion.23 These facts, however, are not evidence sufficient from which a jury could conclude that the source of the ignition was Carter's attempt to light a cigarette in the wingtank. For example, there is no evidence that there was an unsmoked cigarette, or parts of an unsmoked cigarette, on the floor of the wingtank;24 no evidence that the flash explosion would have destroyed the cigarette that Carter allegedly tried to light; no evidence regarding whether a cigarette lighter or matches were found in the wingtank;25 and no evidence that an opened, new pack of cigarettes with one missing was found in the wingtank or on Carter.

In sum, even if it is assumed that Carter and Little did not smell the gas, there is no evidence that fact would support a jury's conclusion that nasal fatigue was the reason. The record simply supplies no answers of any kind whatsoever, and does not begin to suggest which of the speculative theories for their remaining in the tank is most plausible. In the absence of evidence on the various points we have noted above, nasal fatigue remains only one of many speculative reasons why Carter and Little remained in the wingtank, knowing that there had been a gas leak.26 Consequently, the district court was correct in determining that the plaintiffs failed to satisfy their burden of coming forth with evidence that would support a jury verdict.

In conclusion, we reiterate that, as the case was pled and presented to the district court, the plaintiffs based their sole theory of recovery on the premise that Little and Carter suffered from nasal fatigue and that their deaths resulted from Liquid Air and Chevron's failure to warn them of this phenomenon. In response to motions for summary judgment, it was therefore incumbent upon them to present evidence--not just conjecture and speculation--that nasal fatigue did occur and that it bore some causal connection with the deaths of Little and Carter.

After the completion of discovery and extensive briefing here and in the district court, however, these salient facts emerge: (1) there was a gas leak in the wingtank; (2) Carter and Little knew of the gas leak; (3) there was an explosion; and (4) if Carter and Little had followed their employer's instructions, and the warning provided by the defendants, to evacuate in the event of a leak, they would not have died. Beyond these facts, what happened, why it happened, and how it happened is only speculation. The plaintiffs simply did not meet their burden to adduce evidence upon which a juror could determine what caused Little and Carter to ignore explicit warnings and safety precautions to evacuate the wingtank when they discovered a gas leak.

Although the panel majority attempted to assume facts and present a theory upon which the plaintiffs might have recovered, it was not free to amend the plaintiffs' pleadings or to assume facts that might be proved but are not established by the record. The absence of evidence to support the plaintiffs' theories of recovery made this case clearly and plainly appropriate for summary judgment. The district court fairly and thoroughly considered the plaintiffs' claims and determined that the complaint should be dismissed. The district court was correct and is therefore

AFFIRMED.

JOHNSON, Circuit Judge, with whom POLITZ, Chief Judge, joins, dissenting:

The majority opinion herein does not contest the panel majority's principal conclusion. That conclusion was that there was a genuine issue of material fact as to whether the warnings on this product were inadequate because they did not warn of the danger that "nasal fatigue" could degrade an individual's ability to detect the presence of the odorized gas. 952 F.2d 841, 850 (5th Cir.1992). Instead, the majority concludes that the evidence that the decedents were affected by nasal fatigue and that nasal fatigue bore a causal relation to the accident was too speculative to survive summary judgment. Maj. op. at 1071.

However, there was circumstantial evidence to support both of these conclusions.1 That evidence showed that the decedents initially smelled the gas in that they discovered the leak. There was also testimony that nasal fatigue is a phenomenon that always occurs, at least to some extent, and that it works to diminish your ability to detect an odor. Additionally, there was evidence that Carter lit a cigarette some time after the leak was discovered which suggests that the decedents could no longer smell the gas.2 From this circumstantial evidence, a jury could readily infer that the decedents' inability to smell the gas, which was obviously present in sufficient quantities to cause the explosion, was caused, at least in part, by nasal fatigue.

Viewed in a light most favorable to the plaintiffs, this writer concludes that this view of the evidence was reasonable, not merely speculative, and for a jury to accept or reject. See Baton Rouge Bldg. & Constr. Trades Council v. Jacobs Constructors, Inc., 804 F.2d 879, 881 (5th Cir.1986) (per curiam) (in reviewing a summary judgment, we must review the evidence and any inferences to be drawn therefrom in a light most favorable to the non-moving party). If this view of the evidence is accepted, then it would be sufficient to raise a genuine issue of material fact as to whether the decedents did, in fact, experience nasal fatigue and whether this bore a causal relation to the accident. Fed.R.Civ.P. 56(c). For these reasons, and for the reasons stated in the panel majority opinion, this writer adheres to the view that summary judgment in this case was inappropriate.

Even if this conclusion is incorrect, though, it is difficult to see why this case merited en banc review. This case announces very little new law. Instead, it simply reiterates the familiar summary judgment standard flowing from the Supreme Court's trilogy of summary judgment cases and then applies that standard to the facts of this case. Celotex Corp. v. Catrett, 477 U.S. 317, 106 S. Ct. 2548, 91 L. Ed. 2d 265 (1986); Anderson v. Liberty Lobby, Inc., 477 U.S. 242, 106 S. Ct. 2505, 91 L. Ed. 2d 202 (1986); Matsushita Electric Industrial Co. v. Zenith Radio Corp., 475 U.S. 574, 106 S. Ct. 1348, 89 L. Ed. 2d 538 (1986). The only real difference between the majority and the dissent herein is the application of the facts of this particular case to that familiar standard. This hardly seems worthy of en banc consideration.

For this additional reason as well, this writer dissents.